Where Is the Antifreeze Overflow on a 79 Corvette
Topic: Possible to have too much coolant?
in Forum: C3 Cooling and Heating Systems
Already a Member? Click Here to Login
Not yet a Member? Click Here to Register for Free!
Possible to have too much coolant? (1/7)
4/20/09 5:07pm
Is it possible to have too much coolant in my system? I just purchased a 69 and the only problem I've really had with it so far is that on hot days it has purged a good amount of radiator coolant from the side discharge jug onto the ground.
The last time it happened I added more coolant and the car ran fine for a couple of days and then today it discharged again.
The car has a brand new radiator, water pump and thermostat.
Is this normal? Am I running too much fluid? I fill the discharge tank to about half.
Thanks
Eric
Our Sponsors help support C3VR
Possible to have too much coolant? (2/7)
4/20/09 6:04pm
kstyer
Lifetime Member
Moderator
Send Private Message
CUYAHOGA FALLS, OH - USA
Vette(s):
1975 C3 Red, T-Tops, Black Interior. All I need is time and money! Getting there!
Joined: 12/2/2003
Posts: 6415
Yes, you can overfill the system.
If you have an overflow tank (discharge tank) you keep the radiator completely full.
But you need to leave some space in the overflow tank. Coolant expands when it gets hot, and it needs to go somewhere. If the tank is too full, yes it will dump some coolant on the ground.
As the system cools, it shrinks volume, creates a vacuum, and pulls coolant back into the radiator.
How full is the tank before it happens? How much is in the tank when it cools back off?
If you have a cap for a non overflow tank system, it will dump on the ground when the coolant expands. With the right cap, it should balance out the system.
When you fill to 1/2, is that with the engine cold or hot. Cold, it could be the issue. Hot should be fine at that level.
A weak pressure cap will cause the problem with a other wise good system.
Possible to have too much coolant? (3/7)
4/20/09 7:13pm
Thanks for the reply.
The overflow tank says to fill half full when cold. I don't beleive the overflow tank was replaced when the new radiator was added in March. It sort of makes me wonder if the overflow tank is too small or too old for the new radiator. The cap looks fairly old and I am going to replace that either way but I am going to look into finding out weather I have the correct overflow tank for the current radiator I have.
Possible to have too much coolant? (4/7)
4/20/09 7:43pm
Jaws79
Lifetime Member
Send Private Message
Sykesville, MD - USA
Vette(s):
1979 Corvette Coupe Corvette Light Blue Midnight Blue interior Mirrored Glass T-tops
Joined: 4/27/2008
Posts: 4232
Make sure the antifreeze is diluted properly. Mine was too pure antifreeze and it was like syrup and did not cool properly. Put the proper mix in and no problems since!
Barry
______________
"Down on the Boardwalk...
(Click image to see a larger version}
Lifetime Member #181
Possible to have too much coolant? (5/7)
4/25/09 10:31am
ANTIFREEZE DOESN'T DISAPATE HEAT AS GOOD AS WATER, IN THIS CASE MORE IS NOT BETTER, BECAUSE MY CAR IS KEPT INSIDE AND WHERE I LIVE I DON'T HAVE TO WORRY ABOUT EXTREME FREEZEING COLD I RUN 1/3 COOLANT, 2/3 WATER, 1 BOTTLE PRESTONE COOLING SYS LUBE, 25LB. CAP, NORMAL DAY RUNS 180-90, HOT DAY 112-115*WEATHER 210-220, HIGHER CAP PRESSURE RAISES BOILING POINT.
Possible to have too much coolant? (6/7)
4/25/09 9:50pm
Norsky
Lifetime Member
Moderator
Send Private Message
Twin Lakes, CO - USA
Vette(s):
SOLD - "The Toy" - 1970 Convertible
SOLD - "The Beast" - 1990 ZR-1 (#682)
"BLKBRRD" - 1978 Trans Am, 400ci/225hp, 4 spd, Black w/black interior, Hurst t-tops
Joined: 1/23/2002
Posts: 6964
If your system is like the one on my '70 you should have an expansion tank (which is where you check the coolant level)
andan overflow tank/bottle (which catches the excess coolant).
If things are running that hot check to make sure the fan shroud is in place and the gaps around the radiator are filled in. Sounds like there isn't enough air getting pulled through the radiator to keep things in balance.
______________
Jim Olson
"The Toys"...!!!Save the Wave! 
Where I've been in a Corvette...!!!
Possible to have too much coolant? (7/7)
4/29/09 1:28pm
gsfowler
Former Member
Send Private Message
N. Scituate, RI - USA
Vette(s):
1971 roadster 4 speed blue with white top 1990 roadster 6 speed white on black
Joined: 2/24/2006
Posts: 30
Derics Dad if your expansion tank reaches it't operating temp. and doesent doil over any more,or to a point that the tnak isempty you are ok ie:half tank usual.
however if you have the right cap [17lb] for an expansion tank and you still over heat ,look at all the gaskets around the rad. make shure they are all their .next make shure the fan shroud is pushed in as close to the rad. as possible.
If you are still having problems of boiling over I would have your fule air rachieo checked you could be running to lean
Our Sponsors help support C3VR
Official C3 Vette Registry Community:
Home | Forums | Email | Who's Online
Clubs | Events | Member Stats
Other Official C3 Vette Registry Areas:
Members | Research | Shop
My Account | About C3VR
Other Official Vette Registry Sites:
C4 Vette Registry | C6 Vette Registry
Find us on Facebook
Corvette is a registered trademark of the General Motors Corporation(GM) & Chevrolet Motor Division. Vette Registries, LLC is responsible for all site content (except for member submitted content or where otherwise noted) and does not claim or imply that Chevrolet or GM is responsible for Official C3 Vette Registry content. Vette Registries, LLC is independent from GM and is not affiliated with, sponsored or supported by GM. Copyright/trademark/sales mark infringements are not intended, or implied and are in fact used to support GM, Chevrolet and Corvette. Official C3 Vette Registry content is Copyright 2001-2019, Vette Registries, LLC. Content may not be reused without written consent. All Rights Reserved. NS
Corvette (Vette) Model Years on this site: 1968 1969 1970 1971 1972 1973 1974 1975 1976 1977 1978 1979 1980 1981 1982
Where Is the Antifreeze Overflow on a 79 Corvette
Source: https://www.c3vr.com/vrforums/possible-to-have-too-much-coolant_message349538.html